Red Bull still needs fix for 'flappy' wing problems

Red Bull has admitted it is still chasing a fix for the ‘flappy’ rear wing problems that it has suffered from at recent Formula 1 events.

The Milton Keynes-based squad has faced a run of issues with its medium downforce configuration in the last few grands prix, which have given it headaches throughout practice.

TV images have shown the top element of the rear wing flapping when DRS is open, with the problem appearing to be caused by the actuator element not being able to cope with the forces being put through it.

The issues in practice in Qatar came before Red Bull switched to its high downforce wing from qualifying onwards, which is a design it knows can be run without drama.

However, the next races in Saudi arabia nd Abu Dhabi will likely lean towards a low or medium downforce requirement, which puts some pressure on Red Bull to ensure its problems in that configuration do not return.

Team principal Christian Horner said after the race in Qatar that going with the higher downforce option was what it wanted for there anyway – but is aware that it could need to use its more troublesome wing at the next venues.

“That was our preferred wing and it was the setup direction we wanted to go in,” said Horner about the change for the high downforce version.

“If those other wings are required in either Jeddah or Abu Dhabi, obviously we’ll need to have fixes in place to straighten them up, and the DRS mechanism.”

Red Bull’s ability to get on top of the problems are not helped by the fact the DRS actuator is an homologated component for 2021, so it is not possible to change the design at this stage, even though a fix would in theory be simple.

Horner is confident, however, that the matter will not cause his team too much of a problem to resolve.

“I think from a reliability point of view it should be relatively straightforward to sort out those actuators,” he said. “We’ve been using them for many years now, so it's not a new technology.”

Explaining Red Bull’s wing problems

The issue in question revolves around the rear wing’s top flap starting to flutter when DRS is in operation.

This fluttering occurs when the DRS actuator and linkage is unable to remain stable, owing to the loads imparted on the assembly.

Whilst it’s doesn’t offer a performance advantage, so there’s no suggestion of it being an attempt to get around the rules, the flapping is something that Red Bull would not want to carry in to a race for fear of the FIA getting involved on safety grounds.

Red Bull Racing RB16B DRS actuator and linkage comparison

Red Bull Racing RB16B DRS actuator and linkage comparison

Photo by: Giorgio Piola

Red Bull, just like everyone on the grid this season, has two rear wing adjuster designs at its disposal, with the FIA having included the DRS actuator and linkages in the homologation list for 2021.

In order for these to be redesigned, teams would be required to spend one of the two development tokens at their disposal. Red Bull spent its tokens at the start of the season on a new gearbox carrier.

This means the designs have been carried over from the freeze point in mid 2020. While the general design and layout of Red Bull’s rear wings haven’t changed dramatically since then, there are aspects that need to be taken into account.

There’s three main downforce arrangements (high, medium and low) in Red Bull’s pool that we’ve seen used on more than one occasion this year.

Furthermore, there’s also its ultra low downforce arrangement for the Italian Grand Prix (small inset) to consider too, along with various flaps and Gurney options that can be leveraged for a slightly different downforce to drag offset.

In the past, teams could match and evolve the DRS actuator to suit the individual demands of each wing setting; whereas the homologation limits mean that isn’t possible this season.

Read Also:
Red Bull Racing RB16B rear wing comparison

Red Bull Racing RB16B rear wing comparison

Photo by: Giorgio Piola

In Qatar, Red Bull trialled both the high and medium downforce arrangements on Friday, with the team expected to prefer the medium downforce arrangement for qualifying and the race.

However, with the DRS issue persisting throughout FP3, it made the switch to the high downforce arrangement, which meant sacrificing some of its straight line speed.

To give some idea of how detrimental this could have been to performance, Red Bull has only used the high downforce arrangement at two other venues this season - Monaco and Mexico.

Keeping it cool

Red Bull has also made some changes in regard to its cooling over the course of the last few races too, with the cooling outlet beside the rear legs of the halo opened up more than has been the case so far this season.

Red Bull Racing RB16B lower cooling detail
Red Bull Racing RB16B cooling detail

The solution from Red Bull is novel when compared with the rest of the grid, as whilst everyone else has a section of bodywork outboard of the halo leg that can be exchanged for louvred panels of various sizes, depending on the cooling required, Red Bull has placed its inside of the leg.

The overriding factor here, as always, is aerodynamic, as the introduction of heat in this region can have a bearing on the surrounding flow structures.

When cooling isn’t at a premium, it is able to run with the outlets closed off entirely. For the majority of the season it managed with the smaller outlets seen in the image on the left. And, in some cases, it has only required one of the outlets to be open.

However, in Mexico the team increased the opening on both sides of the car, in order to assist the much larger layout deployed at the rear of the car.

In Qatar an asymmetric layout was favoured once more, with a larger outlet on the right-hand side of the car and the smaller one on the left-hand side.

shares
comments

Related video

Promoted: Inside the Jeddah F1 Corniche street circuit
Previous article

Promoted: Inside the Jeddah F1 Corniche street circuit

Next article

Ferrari junior Shwartzman joins Haas F1 for Abu Dhabi rookie test

Ferrari junior Shwartzman joins Haas F1 for Abu Dhabi rookie test
Load comments
The “glorified taxi” driver central to F1’s continued safety push Prime

The “glorified taxi” driver central to F1’s continued safety push

As the driver of Formula 1’s medical car, Alan van der Merwe’s job is to wait – and hope his skills aren’t needed. James Newbold hears from F1’s lesser-known stalwart.

Formula 1
Jan 15, 2022
When BMW added F1 'rocket fuel' to ignite Brabham's 1983 title push Prime

When BMW added F1 'rocket fuel' to ignite Brabham's 1983 title push

There was an ace up the sleeve during the 1983 F1 title-winning season of Nelson Piquet and Brabham. It made a frontrunning car invincible for the last three races to see off Renault's Alain Prost and secure the combination's second world title in three years

Formula 1
Jan 13, 2022
How “abysmal” reliability blunted Brabham’s first winner Prime

How “abysmal” reliability blunted Brabham’s first winner

Brabham’s first world championship race-winning car was held back by unreliable Climax engines – or so its creators believed, as STUART CODLING explains

Formula 1
Jan 10, 2022
The steps Norris took to reach a new level in the 2021 F1 season Prime

The steps Norris took to reach a new level in the 2021 F1 season

Lando Norris came of age as a grand prix driver in 2021. McLaren’s young ace is no longer an apprentice or a quietly capable number two – he’s proved himself a potential winner in the top flight and, as Stuart Codling finds out, he’s ready to stake his claim to greatness…

Formula 1
Jan 9, 2022
How Fangio set the bar for Schumacher and Hamilton in F1 Prime

How Fangio set the bar for Schumacher and Hamilton in F1

Juan Manuel Fangio, peerless on track and charming off it, established the gold standard of grand prix greatness. Nigel Roebuck recalls a remarkable champion.

Formula 1
Jan 8, 2022
How Russell sees his place in the Mercedes-Hamilton F1 superteam Prime

How Russell sees his place in the Mercedes-Hamilton F1 superteam

George Russell joining Lewis Hamilton at Mercedes this year gives it arguably the best line-up in Formula 1 – if it can avoid too many fireworks. After serving his apprenticeship at Williams, Russell is the man that Mercedes team believes can lead it in the post-Hamilton era, but how will he fare against the seven-time champion? Motorsport.com heard from the man himself

Formula 1
Jan 6, 2022
How F1 pulled off its second pandemic season and its 2022 implications Prime

How F1 pulled off its second pandemic season and its 2022 implications

OPINION: The Formula 1 season just gone was the second to be completed under the dreaded shadow of the COVID-19 pandemic, but in many ways it was much more ‘normal’ than 2020. Here’s the story of how the championship’s various organisers delivered a second challenging campaign, which offers a glimpse at what may be different next time around

Formula 1
Jan 5, 2022
The adapt or die mentality that will shape F1's future Prime

The adapt or die mentality that will shape F1's future

As attitudes towards the motor car and what powers it change, Formula 1 must adapt its offering. Mark Gallagher ponders the end of fossil fuels

Formula 1
Jan 3, 2022