Giorgio Piola's F1 technical analysis
Topic

Giorgio Piola's F1 technical analysis

What is behind Red Bull’s rear wing troubles

Amid an intense Formula 1 title battle, Red Bull's nerves have not been helped the past two races by the need from some hasty rear wing repairs.

What is behind Red Bull’s rear wing troubles

At the United States Grand Prix, after FP3, Red Bull discovered a hairline crack in Max Verstappen's rear wing that required some last-minute work before qualifying.

Then, in Mexico last weekend, Red Bull's mechanics were seen furiously working on the wings of both its cars again in a bid to get ready for the Saturday afternoon shootout after seeing some damage following final practice again.

In the end, the Red Bulls took to battle in qualifying with some very visible temporary repairs, which looked like some super-strength tape, on the rear wing.

The solution brought the team some time before a more permanent fix could be done overnight ahead of the race

While back-to-back rear wing problems could point to a concern with the Red Bull design, a detailed look at the situation points to the issues being completely separate.

Austin crack

Sergio Perez, Red Bull Racing RB16B

Sergio Perez, Red Bull Racing RB16B

Photo by: Uncredited

The bumpy surface at COTA was most likely responsible for the cracks that had appeared on the rear wing mainplane at Austin.

There, the team was forced to perform keyhole surgery and then patch up the wing afterwards (red arrows).

This highlights the due diligence that teams must perform in order to stay one step ahead of failures.

But it also posed the question about how far teams are pushing the boundaries in order to find performance, all whilst searching for the durability required to work against the backdrop of the cost cap.

Indeed, Red Bull was not the only team to suffer at the hands of COTA's bumps either, as Fernando Alonso was forced to retire from the race following a stress induced failure of his rear wing assembly.

Rear wing detail of Sergio Perez, Red Bull Racing RB16B

Rear wing detail of Sergio Perez, Red Bull Racing RB16B

Photo by: Uncredited

Red Bull's problems in Mexico appear to have been of a different variety for Red Bull, with repairs hastily made to the outermost section of the top flap (red arrow) and the louvred section of the endplate (blue arrows).

It's worth noting that whilst the louvred endplate has been in Red Bull's high downforce arsenal for some time now, it hadn't featured in Mexico before.

The team did have some teething issues when its first ran it, perhaps owing to the delicate connection to the endplate and where they each meet.

Mexico can be an especially challenging place for cars, with teams going for their highest downforce solution at a track with a very long straight and high speeds.

The maximum load placed on the wing at Monaco, where a similar spec rear wing was last used, is not comparable with the loads it will go through in Mexico, owing to the top speeds they must achieve.

On top of this, the different loads and stresses put through the wing as the DRS is opened and closed are much more extreme in Mexico.

Red Bull itself confirmed that the issues it faced in Austin and Mexico were not linked.

Team boss Christian Horner said about the Mexico issue: "It was a completely different part of the wing.

"It's something that that we haven't seen before. But the guys did a great job to make a modification in the field and the wings have done their job perfectly this weekend."

He added that when the problem came to light after final free practice, the team had to take all the wings off both cars to effect some repairs – and return the best of its components to its two drivers.

This is why Sergio Perez suggested after qualifying that his car had not run with the exact same wing he had used to top FP3.

Red Bull Racing RB16B rear wing broken

Red Bull Racing RB16B rear wing broken

Photo by: Giorgio Piola

"We spotted a repair that needed doing on the wing and so, as a precaution, we made some of the alterations to all the wings that were left back in the pool," said Horner.

"All the wings were taken off the car, obviously, and then the best assemblies were made and put onto the two cars. Plus we'd obviously lost a rear wing earlier in the weekend after Checo's off in P1."

While the next race in Brazil can throw up some challenges for teams, the circumstances that triggered the wing problems for Red Bull in the USA and Mexico are unlikely to resurface there.

shares
comments

Related video

Why Red Bull's Mexico victory underlined a time-tested Newey strength
Previous article

Why Red Bull's Mexico victory underlined a time-tested Newey strength

Next article

FIA: Jeddah F1 circuit will be ready in time for Saudi GP

FIA: Jeddah F1 circuit will be ready in time for Saudi GP
Load comments
The factors that could negate Red Bull's practice gap to Mercedes Prime

The factors that could negate Red Bull's practice gap to Mercedes

Mercedes led the way in practice for Formula 1’s first race in Jeddah, where Red Bull was off the pace on both single-lap and long runs. But, if Max Verstappen can reverse the results on Saturday, factors familiar in motorsport’s main electric single-seater category could be decisive in another close battle with Lewis Hamilton...

Formula 1
Dec 4, 2021
Why Norris doesn’t expect Mr Nice Guy praise for much longer Prime

Why Norris doesn’t expect Mr Nice Guy praise for much longer

Earning praise from rivals has been a welcome sign that Lando Norris is becoming established among Formula 1's elite. But the McLaren driver is confident that his team's upward curve can put him in the mix to contend for titles in the future, when he's hoping the compliments will be replaced by being deemed an equal adversary

Formula 1
Dec 2, 2021
What Ferrari still needs to improve to return to F1 title contention Prime

What Ferrari still needs to improve to return to F1 title contention

After a disastrous 2020 in which it slumped to sixth in the F1 constructors' standings, Ferrari has rebounded strongly and is on course to finish third - despite regulations that forced it to carryover much of its forgettable SF1000 machine. Yet while it can be pleased with its improvement, there are still steps it must make if 2022 is to yield a return to winning ways

Formula 1
Dec 2, 2021
How F1 teams and personnel react in pressurised situations Prime

How F1 teams and personnel react in pressurised situations

OPINION: The pressure is firmly on Red Bull and Mercedes as Formula 1 2021 embarks on its final double-header. How the respective teams deal with that will be a crucial factor in deciding the outcome of the drivers' and constructors' championships, as Motorsport.com's technical consultant and ex-McLaren F1 engineer Tim Wright explains.

Formula 1
Dec 1, 2021
How getting sacked from Benetton made Mercedes' Allison Prime

How getting sacked from Benetton made Mercedes' Allison

He’s had a hand in world championship-winning Formula 1 cars for Benetton, Renault and Mercedes, and was also a cog in the Schumacher-Ferrari axis. Having recently ‘moved upstairs’ as Mercedes chief technical officer, James Allison tells Stuart Codling about his career path and why being axed by Benetton was one of the best things that ever happened to him.

Formula 1
Nov 28, 2021
The remarkable qualities that propelled Kubica’s F1 comeback Prime

The remarkable qualities that propelled Kubica’s F1 comeback

It’s easy to look at Robert Kubica’s second Formula 1 career and feel a sense of sadness that he didn’t reach the heights for which he seemed destined. But as Ben Anderson discovered, performance and results are almost meaningless in this context – something more fundamental and incredible happened…

Formula 1
Nov 27, 2021
The humbling changes Ricciardo made to deliver for McLaren Prime

The humbling changes Ricciardo made to deliver for McLaren

From being lapped by his own teammate in Monaco to winning at Monza, it’s been a tumultuous first season at McLaren for Daniel Ricciardo. But, as he tells STUART CODLING, there’s more to the story of his turnaround than having a lovely summer holiday during Formula 1's summer break...

Formula 1
Nov 26, 2021
The potential benefits of losing the F1 constructors' title Prime

The potential benefits of losing the F1 constructors' title

As the battle continues to rage over the F1 2021 drivers' championship, teams up and down the grid are turning their attentions to the prize money attributed to each position in the constructors' standings. But F1's sliding scale rules governing wind tunnel and CFD use will soften the blow for those who miss out on the top places

Formula 1
Nov 25, 2021