FIA asks teams to review braking systems after Mortara crash

The FIA has asked all Formula E teams to review the causes and effects of possible failures to their braking system following the Diriyah E-Prix crash that hospitalised Edoardo Mortara.

FIA asks teams to review braking systems after Mortara crash

Venturi Racing driver Mortara was taken for precautionary checks after a brake-by-wire (BBW) system fault caused him to crash heavily following a practice start in Saudi Arabia.

As a result, both Mercedes and the cars of customer team Venturi Racing were not allowed to compete in qualifying but were later cleared to start the Sunday night race.

Read Also:

Ahead of the Rome E-Prix double-header, the FIA has asked all teams to check the failure mode and effects analysis (FMEA) of their braking system. Manufacturers must submit a list that considers all scenarios relating to an issue in order to homologate their car.

A bulletin from technical delegate Laurent Arnaud read: “Especially if the driver loses the front brake for any reason (leakage, calliper issue), the system must be able to detect that and activate the rear braking (regen or BBW actuation).”

In Mortara’s crash, the brake pedal was fully depressed, but the front brakes were recorded at zero pressure which was likely the result of a possible leak.

The statement continued: “In the chassis supplier common package, [teams] have the displacement travel sensor from the tandem brake master cylinder. Those sensors must be used to detect any leakage on the brake system.”

Marshals remove the car of Edoardo Mortara, Venturi Racing, Silver Arrow 02, from a barrier after his crash

Marshals remove the car of Edoardo Mortara, Venturi Racing, Silver Arrow 02, from a barrier after his crash

Photo by: Andrew Ferraro / Motorsport Images

The FIA clarified that the root cause of the Mortara shunt had not yet been fully identified but “for the time being there is no concern on the chassis common parts”.

This suggests Mortara's crash was an isolated incident, despite Mercedes works driver Nyck de Vries appearing to suffer a similar issue that caused him to retire from the Mexico City race last season. 

That followed a BBW failure for Daniel Abt during practice at the Autodromo Hermanos Rodriguez last year, which led to a crash that required the former Audi driver to be taken to hospital via helicopter. 

The FIA has also suggested teams run with a paddle that drivers can activate to slow the car in the event of a brake pedal issue. Most teams run with such a set-up already.

DS Performance director Thomas Chevaucher, who replaces FIA-bound incumbent Xavier Mastelan-Pinon, told Motorsport.com: “In addition to that failure mode analysis (FMEA), the FIA recommend going in a mode so that the drivers can slow down the car using a paddle.

“In the case of a very severe multi failure on the braking system, the driver has an opportunity to slow down the car using the regen paddle. This, I would say, is an extra safety compared to a normal [internal combustion engine] car.

“We have the motor that can slow down the car if the brakes cannot for some reason.”

Porsche driver Andre Lotterer stopped on track in Rome with a minute of shakedown remaining due to a brake-by-wire issue.

shares
comments

Related video

New Dragon FE car now expected to debut in Monaco

Previous article

New Dragon FE car now expected to debut in Monaco

Next article

Rome E-Prix: Di Grassi fastest as FP1 ends with major crash

Rome E-Prix: Di Grassi fastest as FP1 ends with major crash
Load comments
How Puebla gave Formula E's new points leader breathing space Prime

How Puebla gave Formula E's new points leader breathing space

With the usual Autodromo Hermanos Rodriguez venue unavailable to Formula E, it visited the little Puebla circuit to keep its foot in the door in Mexico. A near-winner two years ago, Pascal Wehrlein looked in swaggering form throughout the weekend - but a breathless final encounter helped put Edoardo Mortara in the driving seat.

The half-term report cards of each Formula E team in 2020-21 Prime

The half-term report cards of each Formula E team in 2020-21

In an eventful Formula E season, punctuated by rain and energy-conservation controversy, the 12 teams contesting the championship have endured many challenges in the opening seven races. Here's how they've got on across the first half of the season.

Formula E
May 26, 2021
How Formula E stood up to F1 comparisons in Monaco Prime

How Formula E stood up to F1 comparisons in Monaco

OPINION: It was no surprise to anybody that the laptimes achieved by Formula E cars on the full Monaco circuit were much slower than Formula 1. But perhaps the more relevant comparison was in the racing spectacle, where FE delivered in spades.

Formula E
May 12, 2021
How Monaco dealt Formula E a winning hand to cure its hangover Prime

How Monaco dealt Formula E a winning hand to cure its hangover

Formula E faced much criticism in the wake of its maligned Valencia event. In need of a turnaround, the series' first use of Monaco's iconic Formula 1 layout provided it with the injection of thrills required to clear the fog that had enveloped the paddock.

Formula E
May 11, 2021
Why Formula E's Valencia fiasco undermines engineering talent Prime

Why Formula E's Valencia fiasco undermines engineering talent

FIA president Jean Todt wanted more Formula E coverage in the media, and got his wish when the opening Valencia E-Prix proved farcical. Despite attempts to spin the race as teams failing to get their sums right, Formula E and its governing body cannot escape blame - especially when trying to get teams to commit long-term.

Formula E
Apr 27, 2021
How Valencia E-Prix farce gave Formula E an image problem Prime

How Valencia E-Prix farce gave Formula E an image problem

Formula E was under the microscope at Valencia, on its first visit to a permanent circuit. But after a mere nine drivers were left classified following Saturday's Valencia E-Prix, the electric championship once more faced criticism after rising energy deductions and miscalculations produced a farcical affair.

Formula E
Apr 25, 2021
How Vergne and Vandoorne found redemption in Rome Prime

How Vergne and Vandoorne found redemption in Rome

Another Formula E double-header, another double dose of frantic action. While the form guide remains unpredictable following fightback wins for Jean-Eric Vergne and Stoffel Vandoorne in Rome, the speed and consistency of Mercedes – both on and off the track – could have its rivals worried for what is to follow

Formula E
Apr 12, 2021
What Nissan's commitment to Gen3 reveals about Formula E's future Prime

What Nissan's commitment to Gen3 reveals about Formula E's future

Formula E's Gen3 era grid continues to take shape, after Nissan opted to commit to the series for another four years. Nissan's global chief operating officer explains why it has thrown its lot in with FE while other high-profile marques have decided to call it quits.

Formula E
Mar 24, 2021