Toyota reveals both cars suffered electrical glitch at Spa

Toyota has revealed that both TS050 Hybrids suffered the electronic problem that cost the second-placed #8 car more than half a minute in last weekend's Spa FIA World Endurance Championship round.

Toyota reveals both cars suffered electrical glitch at Spa

Pascal Vasselon, technical director of the Toyota Gazoo Racing Europe team, explained that the issue that temporarily put the TS050 engine into a protection mode hit the the winning #7 car driven by Mike Conway, Kamui Kobayashi and Jose Maria Lopez on one occasion compared with twice for the sister car. 

The time loss for Kobayashi when the #7 Toyota encountered the problem at the end of the third hour was minimal because, said Vasselon, he was "faster to react". 

Read Also:

Kobayashi and Brendon Hartley, who shared the #8 TS050 with Sebastien Buemi and Kazuki Nakajima, exited the pits together after a safety car just before the three-hour mark. 

Both cars struggled to get up to speed, before Kobayashi raced away from his teammate after going through a series of reset procedures. 

Hartley was unable to get up to full speed until he was halfway along the Kemmel Straight after Eau Rouge and finished his out lap 40s down on his teammate. 

Buemi had run into the same problem in the initial stages of the race, losing approximately five seconds while leading in the wet conditions after the safety car start.

Vasselon said that Toyota had identified the problem resulting in "a lack of engine torque when accelerating from very low speed", but did not understand why it had occurred. 

"We know what the problem is, but we don't know all the details," he said. "It is an engine protection mode that was triggered in some cases.

"It was present on both cars, maybe a bit more severe on #8, but it was in the background on both cars."

#7 Toyota Gazoo Racing Toyota TS050: Mike Conway, Kamui Kobayashi, Jose Maria Lopez

#7 Toyota Gazoo Racing Toyota TS050: Mike Conway, Kamui Kobayashi, Jose Maria Lopez

Photo by: JEP / Motorsport Images

Vasselon explained that there is "a procedure to go through to get away from it, a matter to go through". 

Toyota had never experienced the problem with the TS050's twin-turbo V6 before last weekend's Spa 6 Hours, but it did happen to #8 on one occasion during practice for the event. It suggested that the issue was related to "circuit-specific settings". 

The #7 Toyota ended up winning by 34s after Buemi had to make a late splash-and-dash fuel stop two laps before the chequered flag, although the positions of the two Toyotas had been frozen at the previous round of pitstops with 40 minutes left on the clock. 

Nakajima had been just over a second behind Lopez at this stage after the fourth and final safety car of the race closed up the two Toyotas again. 

The turning point of the race in the favour of #7 came in the opening hour when Conway was given slick tyres on a drying track, while Buemi was left on the wet-weather Michelins he had started the race and had to make an extra pitstop. 

This allowed Conway to build a lead over the sister car of 50s, which stood at well over a minute in Kobayashi's favour when the safety car was deployed the end of third hour.

shares
comments
ByKolles hails "best ever performance" in LMP1 at Spa

Previous article

ByKolles hails "best ever performance" in LMP1 at Spa

Next article

Ferrari "still open" to building Le Mans Hypercar

Ferrari "still open" to building Le Mans Hypercar
Load comments
Charting 100 world championship sportscar starts for Toyota Prime

Charting 100 world championship sportscar starts for Toyota

This weekend's Portimao 8 Hours round of the FIA World Endurance Championship marks the 100th world champion prototype start for Toyota. Here are the major milestones on the road to three figures since the earliest low-key days of its entry into the Group C arena nearly 40 years ago.

WEC
Jun 12, 2021
The philosophical problems the WEC's new Hypercar class is already facing Prime

The philosophical problems the WEC's new Hypercar class is already facing

Most of the column inches after the World Endurance Championship's opener were centred around the relative pace of the Hypercar class and the LMP2s, but there's another question that needs addressing in order for the new division to have a successful future

WEC
May 7, 2021
How stumbling Toyota drew first blood in the WEC's new era Prime

How stumbling Toyota drew first blood in the WEC's new era

Amid concerns that the new Hypercar class would be upstaged on debut by the spec LMP2 machines at Spa, Toyota delivered the pole and victory that the vast majority of observers expected. But neither car had a clean run, which gave the grandfathered Alpine LMP1 an unexpected shot at glory.

WEC
May 4, 2021
What to expect from sportscar racing's bold new Hypercar era Prime

What to expect from sportscar racing's bold new Hypercar era

A slim field of three cars will be entered in the Hypercar class for the first round of the World Endurance Championship's post-LMP1 age. But there are plenty of reasons for optimism with the new wave of manufacturer entries and competing class philosophies just around the corner

WEC
Apr 29, 2021
How Aston Martin scaled new heights in the Prodrive era Prime

How Aston Martin scaled new heights in the Prodrive era

The 2021 FIA World Endurance Championship kicks off at Spa this weekend, but for the first time since its 2012 inception there will be no factory-run Aston Martins in the GTE Pro class. That's especially notable because as a works entity, the Prodrive era of Aston Martin Racing that began in 2005 has been a success from the very start.

WEC
Apr 27, 2021
How 'Brilliant' Bob Wollek lived up to his nickname Prime

How 'Brilliant' Bob Wollek lived up to his nickname

Sportscar racing lost one of it's greatest talents 20 years ago today when Bob Wollek was knocked from his bicycle prior to the Sebring 12 Hours. The enigmatic Frenchman never won the Le Mans 24 Hours, but many still remember today why 'Brilliant Bob' became a legend

WEC
Mar 16, 2021
How Ferrari's Hypercar project could bolster Leclerc's legacy Prime

How Ferrari's Hypercar project could bolster Leclerc's legacy

Ferrari's planned return to the top category at the Le Mans 24 Hours has further heightened anticipation for the 2023 race. Few concrete details are currently known, but already it has a high-profile superstar angling for involvement, which would make a refreshing change

WEC
Mar 5, 2021
Why Ferrari is ending its 50-year top-flight sportscar racing exile Prime

Why Ferrari is ending its 50-year top-flight sportscar racing exile

Making a return to top-flight sportscar racing after 50 years away, Ferrari will enter the Le Mans Hypercar ranks in 2023. The Italian marque denies the link with Formula 1's new cost cap that frees up resources, but it's certainly no coincidence...

WEC
Feb 25, 2021