Problem discovered behind Lotterer's battery overheat DNF

Andre Lotterer's retirement from ABB FIA Formula E's Berlin race was caused by an improper connection in his DS Techeetah car's battery cooling circuit, which triggered a temperature spike.

Problem discovered behind Lotterer's battery overheat DNF

Lotterer had risen to 11th place from 21st on the grid when he pulled into the pits to retire with a quarter of the race remaining in the event in the German capital on Saturday.

The title-contending German explained that he had stopped the car as his battery’s temperature continued to rise in the closing stages and was approaching the 72°C mark - the point at which the Gen2 car loses power dramatically and shuts down.

"It was steadily building - it can happen sometimes, maybe if you're in traffic or something - but it kept rising," Lotterer told Motorsport.com.

"The full course yellow cooled it a bit, but immediately when we went back to green it was rising [again].

"We parked the car at 71.7°C - at 72°C the system collapses and the car will stop. It's a pity about the technical issue, [but] nothing you can do."

A post-race investigation confirmed that it was not a problem with the battery itself, but part of the battery cooling circuit was not connected correctly.

This led to an eventual pressure build-up and resulting failure of one of the external cooling hoses.

The cooling capacity of battery was therefore compromised and as the battery temperatures rose, it protected itself by limiting the power and causing Lotterer's eventual retirement.

It is not believed that the battery has any damage or further issue, and it is expected to remain in the car for Bern.

Lotterer's DNF capped a difficult day in Berlin for the triple Le Mans 24 Hours winner, who had entered the weekend one point off the championship lead.

In group qualifying, he crossed the line too late and did not get to set at time at 250kW in the first group.

Eventual race winner Lucas di Grassi, Jean-Eric Vergne and Lotterer took two warm-up laps before switching to 250kW, with Lotterer missing out on his flying lap by a fraction of a second.

Lotterer felt he was "probably a bit on the edge for going out, but it was more or less under control without much margin".

"But then Lucas slowed down more than we expected and that backed everything up and I was the one that got screwed," he continued. "Literally, I crossed the line and I thought it was fine because for me I only saw green lights, but just when I passed, tenths before, it turned to red.

"That's modern racing - with the all the systems. I think if we had had a marshal with a flag it would have been fine.

"I don't want to blame Lucas, he did his thing, but he had no one in front of him - he didn't need to slow down like that. It's not the only reason why, but it's one of the reasons."

shares
comments
Berlin E-Prix: di Grassi dominates at Audi's homeground

Previous article

Berlin E-Prix: di Grassi dominates at Audi's homeground

Next article

Massa "disappointed" with run of mistakes in Berlin

Massa "disappointed" with run of mistakes in Berlin
Load comments
The half-term report cards of each Formula E team in 2020-21 Prime

The half-term report cards of each Formula E team in 2020-21

In an eventful Formula E season, punctuated by rain and energy-conservation controversy, the 12 teams contesting the championship have endured many challenges in the opening seven races. Here's how they've got on across the first half of the season.

Formula E
May 26, 2021
How Formula E stood up to F1 comparisons in Monaco Prime

How Formula E stood up to F1 comparisons in Monaco

OPINION: It was no surprise to anybody that the laptimes achieved by Formula E cars on the full Monaco circuit were much slower than Formula 1. But perhaps the more relevant comparison was in the racing spectacle, where FE delivered in spades.

Formula E
May 12, 2021
How Monaco dealt Formula E a winning hand to cure its hangover Prime

How Monaco dealt Formula E a winning hand to cure its hangover

Formula E faced much criticism in the wake of its maligned Valencia event. In need of a turnaround, the series' first use of Monaco's iconic Formula 1 layout provided it with the injection of thrills required to clear the fog that had enveloped the paddock.

Formula E
May 11, 2021
Why Formula E's Valencia fiasco undermines engineering talent Prime

Why Formula E's Valencia fiasco undermines engineering talent

FIA president Jean Todt wanted more Formula E coverage in the media, and got his wish when the opening Valencia E-Prix proved farcical. Despite attempts to spin the race as teams failing to get their sums right, Formula E and its governing body cannot escape blame - especially when trying to get teams to commit long-term.

Formula E
Apr 27, 2021
How Valencia E-Prix farce gave Formula E an image problem Prime

How Valencia E-Prix farce gave Formula E an image problem

Formula E was under the microscope at Valencia, on its first visit to a permanent circuit. But after a mere nine drivers were left classified following Saturday's Valencia E-Prix, the electric championship once more faced criticism after rising energy deductions and miscalculations produced a farcical affair.

Formula E
Apr 25, 2021
How Vergne and Vandoorne found redemption in Rome Prime

How Vergne and Vandoorne found redemption in Rome

Another Formula E double-header, another double dose of frantic action. While the form guide remains unpredictable following fightback wins for Jean-Eric Vergne and Stoffel Vandoorne in Rome, the speed and consistency of Mercedes – both on and off the track – could have its rivals worried for what is to follow

Formula E
Apr 12, 2021
What Nissan's commitment to Gen3 reveals about Formula E's future Prime

What Nissan's commitment to Gen3 reveals about Formula E's future

Formula E's Gen3 era grid continues to take shape, after Nissan opted to commit to the series for another four years. Nissan's global chief operating officer explains why it has thrown its lot in with FE while other high-profile marques have decided to call it quits.

Formula E
Mar 24, 2021
Why the new Formula E season got off to such a controversial start Prime

Why the new Formula E season got off to such a controversial start

With the new Formula E season belatedly getting underway in Saudi Arabia, the championship appeared to try to make up for lost time with an overspill of action and controversy on and off the track. While some talking points could have serious repercussions, it was an explosive opener for many reasons.

Formula E
Mar 1, 2021